Common reasons for inverter not charging

inverter not charging
Image Credits: Wikimedia Commons

It is very difficult to imagine living without an inverter these days, isn’t it? Well when the power supply goes off then it is the inverter that we depend upon to provide us with the required amount of electricity supply for powering important devices like lights, fans and others. But sometimes we face the issue of inverter not charging and this can make matters difficult. There can be many reasons for inverter not charging and it is important to know them so as to get the issue resolved. The following are some of the common reasons for inverter not charging.

1. A dead battery

REASON: One of the most common reasons for inverter not charging is a battery which is dead altogether.

SOLUTION: The only solution for this problem is the replace the battery. This means that the life of the battery is complete and there is no way to repair it. You can easily purchase an inverter battery yourself by either going to the market or ordering it online. You can also ask a professional to replace the battery for you.

Our Pick

If you are looking forward to replace your Batteries, we have some recommendations for you:-

  1. LUMINOUS RC 18000 150 AH Tall Tubular Battery 
  2. V-Guard VJ145 135AH Flat Tubular Inverter Battery 
  3. Exide Powersafe 65AH SMF Battery 
  4. Amaron Inverter 150Ah Tall Tubular Battery
  5. EXIDE INDUSTRIES 150Ah Insta Brite Inverter Ups Battery 
  6. OKAYA HT 7048 (150AH) Tall Tubular Inverter Battery
inverter battery
Image Credits: team-bhp.com

2. Burnt rectifiers

REASON: Another possible reason why your inverter may not be charging is because of burnt rectifiers. Rectifiers are basically step down transformers which tend to get burnt in some cases.

SOLUTION:In this case, you may have to get your UPS repaired. This situation arises if the cooling fan of UPS is not working properly or if the UPS is set at to a great degree hot spot.  Make sure the quality as well as nature of the internal circuitry are good to avoid this problem.

burnt rectifiers
Image Credits:nlvocables.com

3. Melted fuses

REASON: Out of the several reasons for inverter not charging, one could be melted fuses.  The main causes for blown fuses include reverse polarity or short circuit within the appliance. Also if the appliance is being over operated or used, then even in that case the fuse can melt or blow off.

SOLUTION:   In this case, you first need to disconnect the device and then get a new one installed by taking help of a professional. Avoid replacement on your own as it can prove to be complicated.

melted fuse inverter
Image Credits: YouTube.com

4. Loose Battery connections

REASON: Another common reason for inverter not charging could be loose battery connections.  If the battery has been placed slightly loose then the inverter may not charge properly or at all.

SOLUTION: In this case, you must check the battery terminals for corrosion and then clean and clamp them properly.  If you are unable to clean or check the battery terminals yourself, then it is better to take help of someone who is experienced in doing this.

loose battery connections
Image Credits: srisms.com

Inverters are essential devices which must be in proper working condition at all times. In case you are facing any problem related to inverters including the one where your inverter is not getting charged, you must immediately take action and get the issue resolved. There are many good service providers like Mr Right who provide repair related services such as inverter battery backup problem and others.

Our Pick

If you are looking for a new Inverter, some of the other best selling Inverters available online are:-

  1. Luminous Zelio 1700 Inverter with Red Charge 18000 150 Ah Tubular Battery 
  2. Luminous Zolt 1100 Inverter + RC 25000 200 Ah Tall Tubular Battery + Trolley

You might also like

16 Comments

  1. 1

    Sir my luminous eco volt neo 2000va /24v
    charging lights are not responding means not showing that my UPS is charging .but it is pluged in and other lights are lighten and also a sharp noise is produced by the UPS.can u plz give me a solution of it.

  2. 2

    My name is Tokollo, I have installed a Mecer inverter 5000Kv with 4 gel batteries. However, my inverter fails to recharge the batteries. My usage is below. Can one battery affect other batteries not to charge?

  3. 3

    Hello, I appreciate this forum. My own problem is that my inverter can charge my battery using solar energy but can not charge the battery when connected to public electricity from the power company though the charging light/signal is indicating charging.
    Pls I need your advise.
    Thank you.

  4. 4

    I have a 3.5kv luminous sine wave inverter which does not serve. When power supply is off and I switch to the inverter it stays on for only 1hr:30mis then runs down and says battery low.
    When electric supply is back, the inverter indicates charging for 5secs and says battery full.
    Please I need a solution to this problem

  5. 5

    Sir my diesel generator is not charging the battery? The display panel says 25v when off, but when run…it gives me a reading of 23v? What should I do?

  6. 6
  7. 7

    Sir my UPS charging lights are not responding means not showing that my UPS is charging .but it is pluged in and other lights are lighten and also a sharp noise is produced by the UPS.can u plz give me a solution of it.

  8. 8
  9. 9

    Sir my inverter indicate charging light of the battery but once electricity goes off it doesn’t last uptil 5 hours the product is genuine 3.5 kva 48 v

  10. 10

    Inverter not taking and giving back ups and the smart charge blinking does not occur..tried up and down switch..plz send a solution.

  11. 11

    My luminous 850va inverter “charge indicator” led keeps blinking nonstop and the red call button too. It doesn’t charge the 160ah battery too. Help please!

    • 12

      My Fortuner 850VA invertor is connected to the grid and one 12V 150Ah battery without solar panels. It is not charging the battery. What could be the reason?

  12. 13

    Sir my inverter is not charing and its model is luminous 1500 VA UPS RAPID CHARGE what will be the reason behind it plz explain it breifly

  13. 14
  14. 15
  15. 16

Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <s> <strike> <strong>